International E-publication: Publish Projects, Dissertation, Theses, Books, Souvenir, Conference Proceeding with ISBN.  International E-Bulletin: Information/News regarding: Academics and Research

Physicochemical Characteristics of Biocarbons obtained from Nipa Palm (Nypa Fruiticans Wurmb) Leaves

Author Affiliations

  • 1Department of Pure and Industrial Chemistry, Faculty of Chemical Sciences, College of Natural and Applied Sciences, University of Port Harcourt, P.M.B. 5323, Port Harcourt, NIGERIA
  • 22Department of Chemical Sciences, Niger Delta University, Wilberforce Island, P.M.B., 071, Yenagoa, Bayelsa State, NIGERIA

Res.J.chem.sci., Volume 5, Issue (1), Pages 18-26, January,18 (2015)


Physicochemical characteristics are essential in assessing the performance indices of potential biocarbons. In an attempt to find the feasibility of developing an eco-friendly and economically sustainable adsorbent for the removal of contaminants from industrial wastewater; the physicochemical characteristics of biocarbons generated from Nipa palm (Nypa fruticans Wurmb) leaves at the same carbonization temperature with differential chemical - modifications were investigated using standard testing methods. The differentially modified biocarbons were obtained through single step pyrolysis after saturating the biocarbons with H2O, H2SO4 and KOH. The domino-effects obtained show that maximum biocarbon yield of 46.6 ± 0.21 % was recorded for basic reagent surface-modified biocarbon (BAC) followed by acidic reagent modified biocarbon (AAC) with a value of 35.1 ± 0.19%) and physically carbonized biocarbon (PCC) respectively. The data showed that, amongst the Nipa palm derived biocarbons, the BAC had the highest fractional burn-off. The percent ash and moisture contents of biocarbons (PCC: 5.8, AAC: 4.3, BAC: 3.7 for ash content and PCC: 6.5, AAC: 6.4, BAC: 7.1 for moisture content) produced from Nipa palm leaves was relatively low; while pH values of the biocarbons produced and characterized have basic characteristics with pH between 6.41 ± 0.11 to 7.81 ± 0.12 which is within the acceptable pH range of 6 - 8. The density of the biocarbons was in the range of 0.64 – 0.89 g/cm3, while porosity ranged from 66 – 79 % with BAC recording the utmost bulk density (0.89 g/cm3) and porosity (79 %). The BAC biocarbons exhibit lower attrition values and showed higher surface area. The iodine number in mg/g follows the order: BAC (814.5 mg/g) > PCC (622.8 mg/g) > AAC (431 mg/g). The overall results indicate that the type of chemical activating reagent plays a significant role in the physicochemical properties of a particular biocarbon and that impregnating the biomass of Nipa palm with KOH produced the best biocarbon amongst the activating reagents used in this work. This implies that, BAC biocarbon will be a superior adsorbent with high micropore content needed for liquid phase adsorption. The inexpensive Nipa palm leaves biocarbons has characteristics comparable to commercial granulated activated carbon.


  1. Mohamad R., Salmah H. and Teh P. L., Chemicalcomposition of Nypa fruticans filled polylactic acid/recycled low-density polyethylene biocomposts, BioRes., 9(2), 2033–2050 (2014)
  2. Hutton W., Tropical Fruits of Malaysia and Singapore, Periplus Edition (UK) Ltd., 18-25 (1996)
  3. Wankasi D., Spiff A.I. and Horsfall M., Jnr., Sorptionkinetics of Pb2+ and Cu2+ from aqueous solution by Nipapalm (Nypa fructicans Wurmb) shoot biomass, Elect. J.Biotechnol., 9(5), 587–592 (2005)
  4. Wankasi D., Horsfall M., Jnr., and Spiff A.I., Nypa Palm(Nypa fruticans) Thumb Wurmb) : A potentially valuableResource in the Niger Delta Region of Nigeria, Nig. J.Bot., 21(1), 123–127 (2008)
  5. FAO –, Food and Agriculture Organization of the UnitedNations, (1998). Available from :>.Retrieved January, (2009)
  6. Budinova T., Ekinci E., Yardim F., Grimm A., BjφrnbomE., Minkova V. and Goranova M., Characterization andapplication of activated carbon produced from wood byH3PO4 and water vapor activation, Fuel ProcessingTechnol., 87, 899–905 (2006)
  7. Madu P.C. and Lajide L., Physicochemicalcharacteristics of activated charcoal derived from melonseed husk, J. Chem. Pharma. Res., 5(5), 94-98 (2013)
  8. Joshi S., Adhikari M., Pokharel B.P. and PradhanangaR.R., Effects of Activating Agents on the ActivatedCarbons Prepared from Lapsi Seed Stone, Res. J. Chem.Sci., 2(10), 80-86 (2012)
  9. Vitidsant T., Suravattanasakul T. and Damrouglerd S., Production of activated carbon from palm oil shell bypyrolysis and steam activation in a fixed bed reactor, Science Asia., 25, 211-222 (1999)
  10. Dina D.J.D., Ntieche A.R., Ndi J.N., and Ketcha M.J., Adsorption of Acetic acid onto Activated Carbonsobtained from Maize cobs by Chemical Activation withZinc chloride (ZnCl2), Res. J. Chem. Sci., 2(9), 42-49(2012)
  11. Horsfall M. Jnr., Spiff A.I. and Abia A.A., Studies on theInfluence of Mercaptoacetic Acid (MAA) Modificationof Cassava (Manihot esculenta Cranz) Waste Biomass onthe Adsorption of Cu2+ and Cd2+ from Aqueous Solution, Bull. Korean Chem. Soc., 25 (7), 969 – 976 (2004)
  12. Tsai W.T., Chang C.Y., Wang S.Y., Chang C.F., ChienS.F. and Sun H.F., Preparation of activated carbons fromcorn cob catalyzed by potassium salts and subsequentgasification with CO2, Biores, Technol.,78, 203-208(2001)
  13. Sugumaran P., Priya S.V., Ravichandran P. and SeshadriS., Production and Characterization of Activated Carbon from Banana Empty Fruit Bunch and Delonix regia FruitPod, J. of Sustainable Energy and Environ., 125-132(2012)
  14. Ekpete O.A. and Horsfall M. Jnr., Preparation andCharacterization of Activated Carbon derived fromFluted Pumpkin Stem Waste (Telfairia occidentalis HookF), Res. J. Chem. Sci., 1(3), 10–17 (2011)
  15. Abechi S.E., Gimba C.E., Uzairu A. and Dallatu Y.A., Preparation and Characterization of activated carbonfrom Palm Kernel Shell by Chemical Activation, Res. J.Chem. Sci., 3(7), 54 -61 (2013)
  16. Qureshi K., Bhatti I., Kazi R. and Ansari A.K., Physicaland chemical analysis of activated carbon prepared fromsugarcane bagasse and use for sugar decolorisation, Inter. J. Chem. Bimolecular. Engnr., 1(3), 145- 149(2008)
  17. Joshi S., Adhikari M., Pokharel B. P. and PradhanangaR.R., Effects of Activating Agents on the ActivatedCarbons Prepared from Lapsi Seed Stone, Res. J. Chem.Sci., 2(10), 80-86 (2012)
  18. Ash B., Satapathy D., Mukherjee P.S., Nanda B.,Gumaste J.L., and Mishra B.K., Characterization andapplication of activated carbon prepared from coir pith, J. Sci. Ind. Res., 65 1008-1012 (2006)
  19. Cui H., Cao Y. and Pan W.P., Preparation of activatedcarbon for mercury capture from chicken waste and coal, Anal. Appl. Pyro., 80, 319-324 (2007)
  20. Toles C.A., Marshall W.E. and Johns M.M., Surfacefunctional groups on acid activated nutshell carbons, Carbon. 37, 1207–1214 (1999)
  21. AOAC Official Method, Crude protein in animal feed,forage, grain, and oilseeds, block digestion using coppercatalyst, steam distillation into boric acid. AOACInternational, Gaithersburg, MD, (2001)
  22. Rengaraj S., Arabindoo B. and Murugesan V., Preparation and characterisation of activated carbon fromagricultural wastes, Indian J. Chem. Tech., 6(1), 1-4(1999)
  23. Aziza A., Odiakosa A., Nwajei G. and Orodu V., Modification and characterization of activated carbonderived from Bumper sawdust and disk sawdust toremove lead (II) and cadmium (II) effluent water, CSNConference proceeding Chem. Soc. Nig. Deltachem, 235-243 (2008)
  24. ALzaydien A.S., Adsorption of Methylene Blue fromAqueous Solution onto a Low-Cost Natural JordanianTripoli, Amer. J. Environ. Sci., 5(3), 197-208 (2009)
  25. Tamunaidu P. and Saka S., Chemical characterization ofvarious parts of nipa palm (Nypa fruticans), Indus. CropsProd., 34, 1423–1428 (2011)
  26. Gaspa S. and Ncibi M.C., Biomass Applications:Pollution Remediation and Energy, RSC Green Chem.Pub., 25, 52 – 54 (2014)
  27. Shrestha R.M., Yadav A.P, Pokharel B.P. andPradhananga R.R., Preparation and Characterization ofActivated Carbon from Lapsi (Choerospondias axillaris)Seed Stone by Chemical Activation with Phosphoricacid, Res. J. Chem. Sci., 3(3), 34-41 (2013)
  28. Williams P.T. and Nugranad N., Comparison of productsfrom the pyrolysis and catalytic pyrolysis of rice husk, Energy, 25(6), 493-513 (2000)
  29. Qureshi K., Bhatti I., Kazi R. and Ansari A.K., Physicaland chemical analysis of activated carbon prepared fromsugarcane bagasse and use for sugar decolorisation, Inter. J. Chem. Bimolecular. Enginr, 1(3), 145-149(2008)